Engineer
Farabi Petrochemicals Company
Total years of experience :0 years, 9 Months
Commissioning, Testing and Maintenance of the Petra Chillers, Zamil and Carrier. Most frequent job was guidance to the team on tracking of the fault diagnostic in Chillers use for the Industrial applications.
Also conducted comprehensive inspection four new Carrier Chiller for the Riyadh Bank, having capacity each 140 tons.
Chiller Carrier Riyadh Bank Dammam Branch Saudi Arabia.
Independently Investigated performance of four Carrier 140 TONS each
commissioned with the old HVAC structure for all eight floors having six AHU on
each floor. Advised trouble shooting and conduct preventive and corrective
maintenance activities on the Air Handling Units. Directed reports fault such as
water leaks, AHU fan failures and tripping and major cause behind low magnitude of
cooling outputting from each Chiller.
Dhanu Cooling
Diagnostic fault in Petra Chiller: APS A 60-15, Serial No 5813/0101/ 01, R-134, 213
A, flow rate 90 GPM . Evaluated Control diagram for signals on Pressure
transmitters, temperature sensor, supply, suction pressure, out suction pressure,
suction pressure transducer, suction temperature sensor, stepper motor. Testing of the
main conductor for power supply and associated to secondary control circuit. Monitor
voltage appeared on PCN EC3 Emerson Super heat Controller to investigate supply
and digital input 24 volts. Identification of fault that made chiller fails due to
insufficient amount of water in the line and bad sensing of flow and pressure.
Configured set points.
Jacob Zate
Commissioning, Installation of the Trane 7.5 tons FCU. Conduct installation of the duct,
condenser, evaporator pipe, drainage and power section following design amendment.
Lines flash out and leak testing to make sure smooth operation