field service engineer
subcontract ABB SERVICE Co
Total years of experience :17 years, 3 Months
Position: Protection Service engineer
Projects:
• Al HAWIYAH / TAIFF 110kv/13.8kv substation station
• UM ELSALAM / GEDDAH 110kv/13.8kv substation
• AL JAMOOM /MAKAH 110kv/13.8kv substation
• BAHRA /MAKAH 110kv/13.8kv substation
• WADILYAH /TAIFF 110kv/13.8kv substation
• MARADAH Water Treatment Plant / JAZAN
• TABUK Pharmaceuticals Factory / TABOUK
Contractor for ABB Service Company H.V department.
Duties:
o Electrical installation of 110kv C.B
o Upgrade and modifying control circuits and interlocks.
o Scheme pre check and loop check of wiring circuits
o Testing of the new C.B (C.B timing, d/c resistance. insulation test. SF6 gas analysis, mechanism function check, coils MIN voltage and SF6 density monitor alarms…etc.)
o Current transformer testing (primary & secondary looping test).
o Voltage transformer testing.
o SCADA and annunciator alarm testing
o Auxiliary relays
o Power factor / tan delta test.
o Trouble Shooting for electrical circuits
o Power transformer & RMU testing and commissioning
…………………………………………………………………………………………………
From Feb. 2015.up to now (Saudi Arabia KSA)
Position: field Service engineer
Projects:
• Community petrorabikh installation and commissioning 13.8kv SWGR
• Naval base 13.8kv installation and commissioning 13.8kv SWGR
• Islamic port red sea commissioning 13.8kv SWGR
• SAFCO co turn round for 13.8kv SWGR
• GABAL OMER hotels installation and commissioning 13.8kv SWGR
• KAP1 installation and commissioning 13.8kv SWGR
• TAIFF Shohda S/S commissioning 13.8kv SWGR
Contractor for ABB Service Company M.V department.
Duties:
o Electrical installation of 13.8KV SWGR
o Upgrade and modifying control circuits and interlocks.
o Scheme pre check and loop check of wiring circuits
o Testing of the C.B (C.B timing, D\C contact resistance, insulation test., mechanism function check, coils MIN voltage …etc.)
o Protection relay testing (Over current, Earth fault, Deferential, over/under voltage, over/under frequency, .. motor protection .etc)
o Current transformer testing.
o Voltage transformer testing.
o Bus bar testing (insulation test., HI. Pot test, D\C contact resistance.
o Stability test
o SCADA and annunciator alarm testing
o Trouble Shooting for electrical circuits
o Auxiliary relays
From September 2009 till 2013
2 Company : Upper Egypt Electricity Production Company (UEEPC)
Position: Electrical maintenance Engineer
Project: Kureimat II 750 MW Combined Cycle power plant
2×250MW SIEMENS Gas Turbine and 1×300MW Hitachi steam turbine
Duties:
Responsible for PM maintenance and testing of electrical system
Fast action to solve any fault and make fault analysis
Making scheduled checks
Finding and fixing faults and run the system again
Oiling and cleaning machinery and parts
Carrying out quality inspections
Responding immediately to equipment breakdowns
Fixing faults or arranging for replacements to be installed
Siemens AG -Gas turbine
o Mk -TLRI 100/36 Generator type SGEN5-1000A and its auxiliaries
o SEE SEMIPOL® D3 Excitation Equipment.
o SFC -Start Frequency Converter D3.
o BAT - Generator transformers 16.5/240KV (±4*2.5% OFF LTC).
o BBT - Unit auxiliary transformer 6.3/16.5KV (±9*2.5% ON LTC).
o BBE/BBF - NAUTS MV 6.3 KV Switchgear.
o UBA - Power control center (PCC).
o Batteries, battery chargers and ups.
o XKA - Emergency diesel generators.
o MV 6.3 KV and LV 0.4kv motors.
o LV 0.4kv load center and MCC motor control center.
o Kidde Fire alarm and firefighting system.
o Automation systems and Local control cabinets.
o 220 KV substations testing of circuit breakers.
HITACHI Steam Turbine
o Generator
o Main Transformer
o Generator Circuit Breakers
o Motor control centers
o Sump pump local control cabinets
o MV 6.3 KV and LV 0.4kv motors.
From September 2008 till September 2009
2 Company : Skoda PRAHA a.s
Position: Electric power Construction / commissioning Engineer
Project: NEW TALKHA power station 750 MW Combined Cycle
Duties:
Responsible for construction and commissioning engineer for HRSG and BOP.
SKODA PRAHA - Heat Recovery Steam Generation HRSG.
o High pressure feed water pump motors.
o Low pressure feed water pump motors.
o Fire alarm system KIDDE Vega CZN network panel.
o Motor control centers MCC.
o AUMA motorized valves.
o Local control panels
o Lighting and power distribution system of HRSG
o Interface pumps protection signals with control system DCS.
o air craft warning light system of stack
From Feb 2007 till September 2008
2 Company : Upper Egypt Electricity Production Company (UEEPC)
Position: Electric power Construction / commissioning Engineer
Project: El Kureimat II 750 MW Combined Cycle power plant
Duties:
Responsible for construction of the combined cycle module
Responsible For “Electrical Drawings Review and Approval "According to the Contract Specification Requirements.
Coordination and Supervision of all Contractors Electrical Works and Identify any deviation from the contract.
Experiences
2Instructor in ISCOSA Training Center (SA-DAMMAM) and conducted the following courses:
o Generator Maintenance
o Industrial Switchgear Troubleshooting Maintenance & Testing
o Basics of circuit breaker
o Circuit breaker maintenance
o Calibration of electric meters
o Low and Medium Voltage Switchgear
o Electrical power transformer maintenance and testing
2Instructor in OGS (oil & gas skills) Training Center (Egypt) and conducted the following courses:
o Un interruptible power supply ups
2 Computer skills:
o Windows
o Microsoft Office
o Internet searching,
o network Fundamentals
2 Additional Skills:
o Ability to work in a group or individually according to the job requirements.
o Self Motivated
o Advanced Research Abilities
o Communications Skills
o Preferred hand work at site than paper work
2 Languages
o Arabic Native Language
o English Very Good
Educational Degree: B.SC. In Electrical Power& M/C Engineering University: HELWAN. Year of Graduation: May 2006. B.SC Grade: Very Good. Graduation Grade: Very Good. • The Project Title: Power Distribution System. Subject: Interior and Exterior Illumination System. Grade: Excellent. • Current Job: - Electrical Construction and Maintenance Engineer
بكلاريوس هندسة الات الجر والقوى الكهربية جامعة حلوان تقدير عام جيد جدا مشروع تصميم المنظومة الكهربية لقرية سياحية تقدير المشروع امتياز